2001 2002 2003 Ford Explorer Sport Trac Service and Repair Manual DVD

Be confident while working on your vehicle, that you are working with a factory manual that covers every last screw, fastener and manufacturer part.

This service and repair manual will walk you through almost every possible repair and maintenence procedure for your vehicle. The DVD contains all manufacturer information needed for complete vehicle service and overhaul.

• Wiring diagrams
• Complete mechanical service information
• Detailed illustrations
• TSBs
• Emission
• PC/ED for fault code testing and reading

DVD Contents:

1. General Information

SERVICE INFORMATION: IDENTIFICATION CODES,JAC KING & LIFTING, NOISE, VIBRATION, HARSHNESS...

2. Chassis

FRONT SUSPENSION, REAR SUSPENSION, RIDE HEIGHTS, WHEEL ALIGNMENT, WHEEL STUDS, WHEEL HUB & BEARING, LOWER ARM, STABILIZER BAR, DRAG LINK, WHEEL KNUCKLE, BALL JOINTS, STRUTS AND SPRING ASSEMBLY, FRONT HALFSHAFTS…

3. Brake System

HYDRAULIC, MASTER CYLINDER, BOOSTER, FRONT DISC BRAKES, REAR DISC BRAKES, CALIPER, ANCHOR PLATES, PARKING BRAKE SYSTEM, BRAKES PRESSURE CONTROL VALVE, BRAKE TUBING, BRAKE HOSE, ANTI-LOCK BRAKE SYSTEM, TROUBLESHOOTING, SYMPTOM CHARTS, PINPOINT TESTS, COMPONENT TESTS, BLEEDING COMPONENTS, BLEEDING SYSTEM, HYDRAULIC LEAK CHECK...

4. Steering

STEERING SYSTEM, POWER STEERING, STEERING GEAR MOUNTING, POWER STEERING GEAR IDENTIFICATION, POWER STEERING PUMP ID, RESERVOIR, PUMP, PULLY-PUMP, HOSE, COOLER FLUID, GEAR, MODULE, IGNITION SWITCH LOCK CYLINDER, WHEEL, AIR BAG SLIDING CONTACT, STEERING SHAFT, STEERING COLUMN SWITCHES, LCM DIAGNOSTIC TROUBLE CODES, MULTIFUNCTION SWITCH...

5. Powertrain Engine / Fuel Stystms

CAMSHAFT, INTAKE MANIFOLD, VALVE COVER -RH, VALVE COVER -LH, CRANKSHAFT PULLY, CRANKSHAFT FRONT OIL SEAL, WATER PUMP, VALVE, HYD LASH ADJUSTERS, ROLLER FOLLOWERS, EXHAUST MAIFOLDS, OIL FILTER ADAPTERS, OIL PAN, OIL PUMP SCREEN, FLEXPLATE, CYLINDER HEADS, PISTONS, THERMOSTAT-WATER, THERMOSTAT- MECHANICAL, RADIATOR LEAK TEST, HYD COOLING FAN, BLOCK HEATER, RADIATOR, FAN MOTOR, THROTTLE BODY, FUEL INJECTORS, SUPPLY MANIFOLD, PRESSURE RELIEF VALVE- FUEL, BELTS, BELT TENSIONER, BELT IDLER PULLYS, IGNITION SYSTEM, INGINTION COILS, SPARK PLUGS, EGR VALVES, PCV VALVES, AIR INTAKE, AIR SYSTEMS, ENGINE AIR CLEANERS, RESONATOR-ENGINE AIR INTAKE, EVAPORATIVE EMISSIONS SYSTEM, EXHAUST BRAKE SOLENOID, VALVE-FUEL VAPOR CONTROL TUBE ASSEMBLY, CANISTER PURGE VALVE, CAMSHAFT POSTITION SENSOR, POWER STEERING PRESSURE SWITCH, FUEL SYSTEMS, PRESSURE RELIEF - FUEL, DRAINING FUEL, PUSH CONNECT FITTING- FUEL, HARIPIN CLIPS- FUEL, VAPOR TUBE FITTING- FUEL, PEDAL, CABLE, CABLE BRAKCET ACCELERATOR, VEHICLE SPEED CONTROLER, ACTUATOR, SPEED CONTROL SERVO, ACTUATOR - SPEED…

6. Powertrain Transaxle / Exhaust

CHAIN COVER, PUMP SHAFT, MAIN CONTROL VALVE BODY-PUMP, PUMP ASSEMBLY, DRIVEN SPROCKET SUPPORT, SUN AND SHELL ASSEMBLY, FORWARD CLUTCH CYLINDER, REVERSE CLUTCH, PLANT ASSEMBLY, OVERDRIVE SERVO, TORQUE CONVERTER, END PLAY CHECK, COOLER FLUID, EXTERNAL CONTROLS, CABLE ADJUSTMENTS, SHIFT SPECS, MUFFLER, TAILPIPES, CATALYTIC VONVERTERS, SPRING HANGERS...

7. Electrical

CLIMATE CONTROL SYSTEMS, AIR DISTRIBUTION AND FILTERING, HEATING AND DEFROSTING, CONTROL COMPONENTS, SPRING LOCK COUPLING, LEAK DETECTION - USING AUTOMATIC CALIBRATION ALOGEN LEAK DETECTORS, LEAK DETECTION - USING TRACER DYE, DISCHARGIN AND RECOVERY, FLUSHING, EVACUATION AND CHARGING, REFRIGERANT SYSTEMS FILTERING - A/C, REFRIGERANT OIL ADDING, VACUUM HOSE REPAIR, REFRIDGERANT ID TESTING, FILTER - CABIN, REGISTERS, DUCT SYSTEMS, DOOR A/C TEMP CONTROLS, DOOR HEATER AIR DAMPER, PLENUM CHAMBER, HEATER HOSE, BLOWER MOTOR, HEATER CORE, AIR CONDITIONING, COMPRESSOR, CLUTCH AND CLUTCH FIELD COIL, EVAPORATOR CORE, SUCTION ACCUMULATOR/DRIER, A/C CYCLING SWITCH, A/C PRESSURE TRANSDUCER, PRESSURE RELIEF VALVE, CONDENSER CORE, MANIFOLD AND TUBE ASSEMBLY, ACTUATOR, BLOWER MOTOR SPEED CONTROL, VACUUM CONTROL MOTOR...

8. Electrical - Battery, Audio, Lighting

CHARGING SYSTEMS FOR BATTER, MOUNTING, CABLE INSTRUCTIONS, GENERATOR, REGULATOR, TROUBLESHOOTING GUIDE, AUDIO SYSTEMS, INSPECTIONS, ACM PARAMETER ID INDEX, PINPOINT TESTS, SYMPTOM CHART, CLEANING, COMPACT DISC CHANGERS, AMPLIFIERS, SUB-WOOFER, AUX STERRING WHEEL CONTROL, ANTENNA, GRID WIRE REPAIR, ISO MODULE, ANTENNA CABLES, SPEAKERS, DOOR SPEAKERS, EXTERIOR LIGHTING, INTERIOR LIGHTING, DAYTIME RUNNING LAMPS, STOPLAMPS, TURN SIGNAL, HAZARD LAMPS, PARKING, REVERSING, BULB ASSEMBLY, LAMP ASSEMBLY, LAMP SWITCH, BRAKE PEDAL POSITION SWITCH…

9. Body and Paint

BODY, FRONT END PANELS, BODY CLOSURES, INTERIOR TRIM, EXTERIOR TRIMS, MIRRORS, SEATING, GLASS, FRAME, INSTRUMENT PANEL, CONSOLE, HANDLES, LOCKS, LATCHES, MECHANISMS, KEYLESS ENTRY, COMPUTER OPERATED LOCKS, WIPERS, WASHERS, SLIDING ROOF, BUMPERS, OCCUPANT RESTRAINTS, AIR BAG SYSTEMS, FRAME ASSEMBLY, SUB FRAME ASSEMBLY, UNDERBODY...

10 Wiring Diagrams

ALL AREAS OF WIRING, CONNECTORS, COMPONENTS, SPLICES, GROUNDS, AIR BAGS, AIR SUSPENSIONS CONTROL SYSTEMS, ANTI THEFT, MIRRORS, RUNNING LAMPS, TEMP CONTROL, ENGINE CONTROLS, EXTERIOR LAMPS, FUSE PANEL, A/C, HEATER, AUTOLAMPS, CHARGING SYSTEMS, COURTESY LAMPS, ELECTRIC SHIFT CONTROL, ENGINE, FOG, GROUNDS, IGNITION SYSTEM, INSTRUMENT ILLUMINATIONS, WIPER/WASHERS, PARKING AID, LOCKS, WINDOWS, DEFROST, LUMBAR SEATS, OVERHEAD CONSOLE, MEMORY SYSTEMS, INSTRUMENT CLUSTER, RADIO, REMOTE CONTROL, SPEED CONTROL, TRAILER, VEHICLE REPAIR CODES, WARNING CHIME, VEHICLE SPEED SENSOR, LAMPS, SHIFT LOCK...

**** FREE SHIPPING ****

**** Windows 98SE, ME, 2000, XP, Vista, Windows 7 (XP Mode) ****

This software is only compatible with Windows 32 bit operating systems. If you are a 64 bit Windows 7user you can run the software in "XP Mode":

To determine if you have a 32 or 64 bit operating system follow these instructions:

Windows Vista or Windows 7

If you have Windows Vista or Windows 7, there are two methods to determine whether you are running a 32-bit or a 64-bit version. If one does not work, try the other.

Method 1: View System window in Control Panel

Click Start, type system in the Start Search box, and then click system in the Programs list.

The operating system is displayed as follows:

For a 64-bit version operating system: 64-bit Operating System appears for the System type under System.

For a 32-bit version operating system: 32-bit Operating System appears for the System type under System.

Method 2: View System Information window

Click Start, type system in the Start Search box, and then click System Information in the Programs list.

When System Summary is selected in the navigation pane, the operating system is displayed as follows:

For a 64-bit version operating system: x64-based PC appears for the System type under Item.

For a 32-bit version operating system: x86-based PC appears for the System type under Item.

If you cannot determine the operating system bit count with these methods, go to the "Next Steps" section.

Windows XP

If you have Windows XP, there are two methods to determine whether you are running a 32-bit or a 64-bit version. If one does not work, try the other.

Method 1: View System Properties in Control Panel

Click Start, and then click Run.

Type sysdm.cpl, and then click OK.

Click the General tab. The operating system is displayed as follows:

For a 64-bit version operating system: Windows XP Professional x64 Edition Version < Year> appears under System.

For a 32-bit version operating system: Windows XP Professional Version <Year> appears under System.

Note <Year> is a placeholder for a year.

Method 2: View System Information window

Click Start, and then click Run.

Type winmsd.exe, and then click OK.

When System Summary is selected in the navigation pane, locate Processor under Item in the details pane. Note the value.

If the value that corresponds to Processor starts with x86, the computer is running a 32-bit version of Windows.

If the value that corresponds to Processor starts with ia64 or AMD64, the computer is running a 64-bit version of Windows.

If you cannot determine the operating system bit count with these methods, go to the "Next Steps" section.

Windows Server 2003

If you have Windows Server 2003, there are two methods to determine whether you are running a 32-bit or a 64-bit version. If one does not work, try the other.

Method 1: View System Properties in Control Panel

Click Start, and then click Run.

Type sysdm.cpl, and then click OK.

Click the General tab. The operating system is displayed as follows:

For a 64-bit version operating system: Windows Server 2003 Enterprise x64 Edition appears under System.

For a 32-bit version operating system: Windows Server 2003 Enterprise Edition appears under System.

Method 2: View System Information window

Click Start, and then click Run

Type winmsd.exe, and then click OK.

When System Summary is selected in the navigation pane, locate Processor under Item in the details pane. Note the value.

If the value that corresponds to Processor starts with x86, the computer is running a 32-bit version of Windows.

If the value that corresponds to Processor starts with EM64T or ia64, the computer is running a 64-bit version of Windows.

If you cannot determine the operating system bit count by using these methods, go to the "Next Steps" section.

_gsrx_vers_457 (GS 6.3.2 (457))